مطالعه موردی کاربرد ویناس برفرآیند تولید کمپوست در فازهای مختلف (در طی تولید و پس از تولید کمپوست)، در مجتمع بازیافت پسماند شهری آراد کوه تهران

نوع مقاله : مقالات پژوهشی

نویسندگان

1 دانشگاه تبریز

2 دانشگاه تهران

چکیده

ویناس ماده‌ای قهوه‌ای رنگ و محصول تولید صنعتی الکل از ملاس‌ها است. ویناس می‌تواند با داشتن مواد آلی و عناصر معدنی زیاد به عنوان مکمل برای افزایش کیفیت کود کمپوست استفاده گردد. این تحقیق با هدف بررسی کاربرد ویناس در سطوح مختلف بر شاخص‌های تولید کمپوست (دما، جمعیت میکروبی، نیتروژن، کربن، نسبت C/N، نیترات، pH و EC) و زمان تولید در در فازهای مختلف (در طی تولید و پس از تولید کمپوست)به مدت پنج ماه در مجتمع بازیافت پسماند شهری آراد کوه (تهران) انجام شد. تولید کمپوست از مواد زائد جامد شهری به روش هوادهی توده ثابت انجام شد. حجم هوادهی‌ در این تحقیق 6/0 لیتر هوا به ازای هر لیتر ماده زائد در دقیقه بود. نتایج نشان داد کمترین زمان رسیدن به دمای ترموفیلیک را تیمار 30 میلی‌لیتر ویناس برای هر کیلوگرم مواد اولیه(C3)و بیشترینراتیمار شاهد(C0)داشت.کاربرد ویناس مقدار نیتروژن کلرا در فاز اول و دوم افزایش داد. تیمار C3 دارای بیشترین و تیمار C0دارای کمترین جمعیت میکروبی بودند. pHو ECتا ماه دوم در تیمارهای C3و 20 میلی‌لیتر ویناس برای هر کیلوگرم مواد اولیه(C2)افزایش و در ماهای سوم تا پنجم کاهش یافت. در فاز دوم در تیمارهای ویناسی افزایش pHو در تیمار C0کاهش pH مشاهده گردید. تیمارC3در فاز اول بیشترین مقدار نیترات را داشت و در فاز دومنیز تیمار C0 بیشترین مقدار نیترات را داشت. در نهایت مشخص شد کهتیمار C3 وC2برای اضافه کردن به بستر پسماندهای آلی مناسب می‌باشد و این تیمارها مدت تولید کمپوست را تا دو ماه کاهش دادند. فاز دوم به‌دلیل عدم توان افزایش قابل ملاحظة نیتروژن نیتراتی و همچنین افزایش pHدر مقایسه با فاز اول مناسب نبود.

کلیدواژه‌ها


عنوان مقاله [English]

Case Study of Survey of Occasional Application of Vinasse in Compost Production in Different Phases (during Production and after Producing Compost), at Waste Resumption Complex of Aradkooh in Tehran

نویسندگان [English]

  • A. Hemati 1
  • H. A. Alikhani 1
  • M. Rasapoor 2
  • H. Asgari Lajayer 1
1 University of Tabriz
2 Tehran University
چکیده [English]

Introduction: Recycling organic wastes has vital roles in sustainable agriculture, reducing pollutants in the environment, and nutrient enrichment of soils. Compost is the product of recycling organic waste through anaerobic treatment, which can be a good alternative.Again the use of chemical fertilizers is inappropriate. Vinasse is brown material and it is a product of industrial production of alcohol from molasses. Vinasse, a by-product of ethanol production from molasses, is a highstrength effluent with a high content of organics, mainly organic acids, reducing substances, cultured matter and glycerol. The wastewater is characterized by high concentrations of potassium, calcium, chloride and sulphate ions, a high content of suspended solids, a high CoD (Chemical oxygen Demand) level and a high temperature at the moment of generation.Vinasse can be used as a supplement for enhancing compost fertilizer quality, because it has plenty of organic matter and minerals. This research was done with the purpose of surveying application of vinasse in different levels on indices of compost producing (temperature, microbial population, nitrogen, carbon, the ratio C/N, nitrate, pH and EC) and producing time in different phases (during the production and after compost production) for 5 months in the waste resumption complex of Aradkooh in Tehran.
Materials and Methods: The method used for compost production from solid waste material was ventilating the fixed mass. In this research, the volume of ventilation was 0.6 lit air for 1 lit waste material in a minute.Four different treatments (each three replicates ) were applied to the compost:C0 without vinasse (control), C1, C2 and C3, respectively 10, 20 and 30 ml vinasse per kg waste material. The following factors were measured during each phase: Total-N was measured by the Kjeldahl method and organic carbon was measured by the Walkley-Black method. Thermometers were used for temperature monitoring at different locations in the riff-raff. The microbial population size was obtained by the CFU method.Electrical conductivity and pH of the water extracts from the samples were determined by shaking the samples mechanically with distilled water at a solid-to-water ratio of 1:10 (w/v). Additionally, NO3–N was determined by spectrophotometric method.
Results and Discussion: At the beginning of this study, theresults showed that, after the formation of the riff-raff, temperature was increasing rapidly all over the riff-raff, which indicates a specified microbial activity. Minimum time to reach the thermophilic temperature, 30 ml per kilogram of vinasse raw materials, was for (C3) and maximum of them was for the control treatment (C0). Adding vinass in the second phase led to an increase in the compost mass temperature. Treatment C3 with the highest and treatment C0 has the lowest microbial populations. Total nitrogen content increased during composting of the waste materials in comparison with its initial concentration. In both phases treatment C3 has the highest and treatment C0 has the lowest total nitrogen content. According to results of the measurements of organic carbon in the first phase, at the beginning of composting process, most of the organic matter was in treatment C3and the lowest organic matter was in C0. However, with increasing the composting process, the vinass treatment had lost jts organic carbon with more gradient. In the second phase by adding vinass, the originally organic carbon increased because of the high levels of organic matter. But,with further vinass treatment, they lost their organic carbon more vigorously. During five months,changes in the ratio of carbon to nitrogen C/Nwas variable. In vinass treatment, the ratio ofC/N increased more vigorously until it reached one quarter and then it fell less sharply. In the first month, this ratio fell less sharply in the control group, and in the final months it fell with more intensity. In the second phase, decreasing the ratio of carbon to nitrogen was observed and the decrease treatment was more than the other treatments. The monthly analysis of riff-raff samples showed that the higher increase in pH mostly occurs in the first month, and in all cases the value of the electrical conductivity increased during composting. Until the second month of pH and EC treatment, C3 and C2 increased and decreased in the third to fifth months.In the second phase pH at vinasse treatment increased and pH at C0 treatment decreased. Maximum amount of nitrate was observed at C3 treatment and at Epsom salt phase nitrate has the maximum amount.
Conclusion: Eventually, it is recognized that treatment C3 and C2it is adequate to add context of organic waste and this treatment decreases the production time of compost up to two months.The second phase was not suitable compared with the first phase due to the inability of increasing nitrate-nitrogen and pH.

کلیدواژه‌ها [English]

  • Compost
  • Fermentation phases
  • Microbial population
  • Nitrate
  • Vinasse
Piccolo A. 1996. Humus and soil conservation. In: Piccolo, A. (Ed.), Humic Substances in Terrestrial Ecosystems. Elsevier, Amsterdam, The Netherlands, pp. 225–264.
2- Azarmi R., Sharifi Z., and Satari M.R. 2008. Effect of vermicompost on growth, yield and nutrition status of tomato (Lycopersicum esculentum).Pakistan Journal of Biological Sciences. 11(14): 1797-1802.
3- Manios T. 2004. The composting potential of different organic solid wastes: experience from the island of crete. Environmental International, 29: 1079-1089.
4- Renkow M., and Rubin A.R. 1998. Does municipal solid waste composting make economic sense.Environmental Management, 53: 339-347.
5- Kaushik P., Yadav Y.K., Dilbaghi N., and Garg V.K. 2008. Enrichment of vermicomposts prepared from cow dung spiked solid textile mill sludge using nitrogen fixing and phosphate solubilizing bacteria. Environmentalist, 28:283–287.
6- Busato J.G., Lima L.S., Aguiar N.O., Canellas L.P., and Olivares F.L. 2012. Changes in labile phosphorus forms during maturation of vermicompost enriched with phosphorus-solubilizing and diazotrophic bacteria.Bioresource Technology. 110: 390–395.
7- Adamtey N., Cofie O., Ofosu-Budu G.K., Danso S.K.A., and Forster D. 2009. Production and storage of N-enriched co-compost. Waste Management, 29, 2429–2436.
8- Ahmad R., Khalid A., Arshad M., Zahir Z.A., and Mahmood T. 2008. Effect of compost enriched with N and L-tryptophan on soil and maize. Agronomy for Sustainable Development, 28 (2), 299–305.
9- Ryznar-Luty A., Krzywonos M., Cibis E., and Miśkiewicz T. 2008. Aerobic Biodegradation of Vinasse by a Mixed Cultureof Bacteria of the Genus Bacillus: Optimization ofTemperature, pH and Oxygenation State. Polish Journal of Environmental Studies. 17(1), 101-112.
10- Madejon E., Diaz M.J., Lopez R., Murillo J.M., and Cabrera F. 1995. Corn Fertilizationwiththree (sugarbeet) vinassecomposts. Fresenius EnvÍr Bull, 4: 232-237.
11- Vadivel R., Minhas P.S., Kumar P.S., Singh Y., Rao D.V.K.N., and Nirmale A. 2014. Significance of vinasses waste management in agriculture and environmental quality- Review.African Journal of Agricultural Research, 9(38), 2862-2873.
12- Bhattacharyya A., Pramanik A., Maji S.K., Haldar S., Mukhopadhyay U.K., and Mukherjee J. 2012. Utilization of vinasse for production of poly-3-(hydroxybutyrate-co-hydroxyvalerate) by Haloferaxmediterranei.Bhattacharyyaet al. AMB Express,2:34.
13- Rasapoor M., NasrabadiT.,Kamali M., and Hoveidi H. 2009. The effects of aeration rate on generated compost quality, using aerated static pile method. Waste Management, 29: 570–573.
14- Page A.L. 1982. Methods of Soil Analysis.Agronomi 9, ASA, SSSA, Madison, Wiscosin, USA.
15- Anonymous. 2005. Compost sampling for lab analysis. Woods End Research Laboratory.
16- Lopez R.J., and Foster. 1985. Plant pathogen survival during the composting ofagriculturalwastes.Composting of Agriculture and Other Wastes. ElsevierApplied Science Publishers, London.
17- Tiwari S.C., and Mishra R.R. 1993.Fungal abundance and diversity in earthworm cast and in uningested soil. Biology and Fertility of Soils, 16, 131–134.
18- Veeken A., Nierop K., Wilde V. D., and Hamelers B. 2000. Characterisation of NaOH-extracted humic acids during composting of a biowaste.Bioresource Technology. 72, 33-41.
19- Pietro M., and Paola C. 2004.Thermal analysis for the evaluation of organic matterevaluation during municipal solid waste aerobic composting process.ThermochimicaActa, 413, 209–214.
20- Aparna C., Saritha P., Himabindu V., and Anjaneyulu Y. 2008. Techniques for the evaluation of maturity for composts of industrially contaminated lake sediments. Waste Management, 28: 1773–1784.
21- Campbell A.G., Flok R.L., and Tripcpi R. 1997. Wood ash as an amendment in municipalsludge and yard waste composting process. Compost Science and Utilization, 5(1), 62–73.
22- Iglesias J.E., Peres G.V., and Fernandez F.M. 1986. The agronomic value off sewagesludgeTenerific composting. Agriculture Wastes, 17: 119–130.
CAPTCHA Image