Investigating the Effect of Wheat Straw Biochar and Hydrochar on Physical Properties of a Sandy Loam Soil

Document Type : Research Article

Authors

• Iman Nikravesh ¹
• Saeid Boroomand Nasab ²
• AbdAli Naseri ¹
• Amir Soltani Mohamadi ¹

¹ Shahid Chamran University, Ahwaz

² Professor, Faculty of Water Sciences Engineering, Shahid Chamran University of Ahvaz, Iran

https://doi.org/10.22067/jsw.v32i2.70445

Abstract

Introduction: Organic matter is considered as the main element for soil fertility by improving the condition of agglomeration, porosity and soil permeability. One of the most useful ways to use plant debris is to turn it into Biochar and Hydrochar. Biochar is a kind of coal produced from plant biomass and agricultural waste that is burned in the presence of low oxygen content or its absence. The hydrothermal process involves heating the biomass or other materials in a pressurized in the presence of water at a temperature between 180 and 250 C, and the result of this reaction is coal (Hydrochar) and soluble organic matter. Biochar and Hydrochar have several advantages such as climate change mitigation through carbon sequestration, soil cation exchange capacity (CEC) increasing, soil fertility, plant growth and root development, improved soil structure and stability, increased soil moisture storage capacity and soil pH adjustment. Coarse soils have large pores and they have low ability to absorb the water and nutrient. The aim of this research was to determine the optimum temperature of wheat straw Biochar and Hydrochar production, and to investigate the effect of these materials on bulk density, total porosity and moisture curve of Sandy Loam soil.
Materials and Methods: In order to produce biochar, at first the wheat straw was washed and dried in the oven. Then it was grinded and was made at different temperatures (200 to 600 ̊ C) inside a furnace for four hours. Similar to biochar, for producing hydrochar, after washing and drying the wheat straw it was grinded into particles ranges from 0.5 to 1 mm. Then it was placed in a stainless steel autoclave with deionized water. The autoclave was heated at different temperatures between 140-230 ̊ C for four hours. The optimum temperature for producing of biochar and hydro-char was determined by using stable organic matter yield index (SOMYI), and it was used in this study. The pH and EC of the biochar and hydro-char samples were measured by combining 1 g of a sample with 20 mL DI water. The cationic and anionic exchange capacity were determined by replacing sodium nitrate with hydrochloric and potassium chloride (Chintala et al., 2013). Surface area was obtained using methylene blue method. A CHNSO Elemental Analyzer (Vario ELIII- elementar- made in Germany) was used to determine the content of C, N, H, S and O in the samples. Potassium and sodium content were measured by flame photometer and calcium and magnesium were measured by titration with EDTA. Biohchar and hydrochar treatments were applied at three levels of 2, 5 and 10 mg / kg soil in three replications in 21 lysimeter. The bulk density, total porosity and moisture curve of soil were measured after four-month irrigation period.
Results and Discussion: According to the calculated value of stable organic matter yield index (SOMYI) at various temperatures in this study, the maximum thermal constancy of wheat straw biochar was 16.20 at temperature of 300 ̊ C and for hydro-char was obtained as 6.13 at the temperature of 200 ̊ C. So, the temperatures of 300 and 200 ̊C were determined as the optimum temperature of sustainable carbon biochar and hydro-char production and were used to continue the experiments of this study. The results showed that addition of HW2, HW5, HW10, BW2, BW5 and BW10 to soil compared to control treatment significantly decreased the bulk density of the soil, 8.97, 11.77, 15.17, 7.9, 10 and 13.10 percent respectively. Also, results showed that addition of HW2, HW5, HW10, BW2, BW5 and BW10 to the soil as compared to control treatment increased soil porosity by 8.8, 11.48, 15.77, 6.48, 9 and 22.13 percent, respectively. The reason for reducing the soil bulk density and increasing the total porosity of soil can be due to the mixing of the soil with materials with a lower bulk density and the effect of increasing the organic matter of the soil due to the use of Biochar and Hydrochar. Based on statistical analysis, wheat straw Biochar and Hydrochar had a significant effect (P

Keywords

• Biochar
• Hydrochar
• Organic matter
• Soil water retention curve

20.1001.1.20084757.1397.32.2.12.8

References

1- Abel S., Peters A., Trinks S., Schonsky H., Facklam M., and Wessolek G. 2013. Impact of biochar and hydrochar addition on water retention and water repellency of sandy soil. Geoderma, 202–203: 183–191.

2- Baiamonte G., De Pasquale C., Marsala V., Cimo G., Alonzo G., Crescimanno G., and Conte P. 2015. Structure alteration of a sandy-clay soil by biochar amendments. Journal of Soils and Sediments, 15: 816-824.

3- Brown R. 2009. Biochar for environmental management: Science and technology. Earthscan: London, UK.

4- Chan KY., Van Zwieten L., Meszaros I., Downie A., and Joseph S. 2007. Agronomic values of green waste bio-chars as soil amendments. Aust J Soil Res, 45:629–634.

5- Chintala R., Mollinedo J., Schumacher T.E., Papiernik S.K., Malo D.D., Clay D.E., Kumar S., and Gulbrandson D.W. 2013. Nitrate sorption and desorption in bio-chars from fast pyrolysis. Microporous Mesoporous Mater, 179: 250–257.

6- Ding Z., Hu X., Wan Y., Wang S., and Gao B. 2016. Removal of lead, copper, cadmium, zinc, and nickel from aqueous solutions by alkali-modified biochar: batch andcolumn tests. J. Ind. Eng. Chem, 33: 239–245.

7- Divband Hafshejania L., Hooshmanda A., Naseria A., Soltani Mohammadia A., Abbasib F., and Bhatnagarc A. 2016. Removal of nitrate from aqueous solution by modified sugarcane bagasse biochar. Ecological Engineering, 95: 101–111.

8- Fang J., Gao B., Chen J., and Zimmerman A. R. 2015. Hydro-chars derived from plant biomass under various conditions: Characterization and potential applications and impacts. Chemical Engineering Journal, 267: 253–259.

9- Gajic´ A., and Koch H. J. 2012. Sugar beet (Beta vulgaris L.) growth reduction caused by hydrochar is related to nitrogen supply. J. Environ. Qual, 41: 1067–1075.

10- Guiotoku M., Rambo CR., Hansel FA., Magalhaes WLE., and Hotza D. 2009. Microwave-assisted Hydrothermal Carbonization of Lignocellulosic Materials. Mater Lett, 63: 2707-2709.

11- Hardie M., Clothier B., Bound S., Oliver G., and Close D. 2014. Does biochar influence soil physical properties and soil water availability? Plant Soil, 376: 347–361.

12- Heilmann SM., Davis HT., Jader LR., Lefebvre PA., Sadowsky MJ., Schendel FJ, et al. 2010. Hydrothermal Carbonization of Microalgae. Biomass Bioenerg, 34: 875-882.

13- Hseu Z. Y., Jien S. H., Chein W. H., and Liou R. 2014. Impacts of biochar on physical properties and erosion potential of a mudstone slope land soil. The scientific world journal, Doi: 10.1155/2014/602197.

14- Kumar S., Masto RE., Ram LC., Sarkar P., George J., and Selvi VA. 2013. Biochar preparation from Parthenium hysterophorus and its potential use in soil application. Ecological Engineering; 55: 67–72.

15- Laird D., Fleming P., Wang B., Horton R., Laird Z., and Karlen D. 2010. Biochar impact on nutrient leaching from a Midwestern agricultural soil. Geoderma, 158: 436–442.

16- Lehmann J., Gaunt J., and Rondon M. 2006. Bio-char sequestration in terrestrial ecosystems – a review. Mitigation and Adaptation Strategies for Global Change, 11: 403–427.

17- Lehmann J. 2007. A Handful of Carbon. Nature, 447: 143-144.

18- Lehmann J., and Joseph S. 2009. Biochar for environmental management: science and technology. Earthscan: London, UK.

19- Lei O., and Zhang R. 2013. Effects of bio-chars derived from different feedstocks and pyrolysis temperatures on soil physical and hydraulic properties. Journal of soils and sediments, 13: 1561-1572.

20- Libra J.A., Kammann Ro. KS., Funke C., Berge A., Neubauer N.D., et al. 2011. Hydrothermal Carbonization of Biomass Residuals: A Comparative Review of the Chemistry, Processes and Applications of Wet and Dry Pyrolysis. Biofuels, 2: 89-124.

21- Liu Y., Zhao X., Li J., Ma D., and Han R. 2012. Characterization of bio-char from pyrolysis of wheat straw and its evaluation on methylene blue adsorption. Desalin. Water Treat, 46: 115–123.

22- Maˇsek O., Brownsort P., Cross A., and Sohi S. 2013. Influence of production conditions on the yield and environmental stability of biochar. Fuel, 103: 151–155.

23- Novak JM., Busscher W.J., Watts D.W., Amonette J.E., Ippolito J.A., Lima I.M., Gaskin J., Das K.C., Steiner C., Ahmedna M., Rehrah D., and Schomberg H. 2012. Biochars impact on soil-moisture storage in an ultisol and two aridisols. Soil Sci, 177(5):310–320.

24- Ouyang L., Wang F., Tang J., Yu L., and Zhang R. 2013. Effects of biochar amendment on soil aggregates and hydraulic properties. Journal of soil science and plant nutrition, 13(4): 991-1002.

25- Rondon M.A., Molina D., Hurtado M., Ramirez J., Lehmann J., Major J., et al. 2006. Enhancing the Productivity of Crops and Grasses while Reducing Greenhouse Gas Emissions through Bio-Char Amendments to Unfertile Tropical soils. Proceeding of the 18th World Congress of Soil Science; Pennsylvania, USA.

26- Sevilla M., and Fuertes A.B. 2009. Chemical and Structural Properties of Carbonaceous Products Obtained by Hydrothermal Carbonization of Saccharides. Chem-Eur J, 15: 4195-4203.

27- Snehota M., Dubovec M., Dohnal M., and Cislerova M. 2009. Retention curves of soil from the Liz experimental catchment obtained by three methods. Soil and Water Res, 4(2): 56-513.

28- Sohi S., Lopez-Capel E., Krull E., and Bol R. 2009. Biochar, climate change and soil: A review to guide future research. CSIRO Land and Water Science Report, 64.

29- Stella Mary G., Sugumaran P., Niveditha S., Ramalakshmi B., Ravichandran. P., and Seshadri S. 2016. Production, characterization and evaluation of biochar from pod (Pisum sativum), leaf (Brassica oleracea) and peel (Citrus sinensis) wastes. Int J Recycl Org Waste Agricult, 5:43–53.

30- Sun Y., Gao B., Yao Y., Fang J., Zhang M., Zhou Y., Chen H., and Yang L. 2014. Effects of feedstock type, production method, and pyrolysis temperature on biochar and hydrochar properties. Chemical Engineering Journal, 240: 574–578.

31- Sun Z., Arthur E., De Jonge L. W., Elsgaard L., and Moldrup P. 2015. Pore Structure Characteristics after 2 Years of Biochar Application to a Sandy Loam Field. Soil Science, 180: 41-46.

32- Tejada M., Garcia-Martinez A., and Parrado J. 2009. Effects of a vermicompost composted with beet vinasse on soil properties. soil losses and soil restoration. Catena, 77(3): 238-247.

33- Titirici M.M., Antonietti M., and Baccile N. 2008. Hydrothermal Carbon from Biomass: A Comparison of the Local Structure from Poly- to Monosaccharides and Pentoses/Hexoses. Green Chem, 10: 1204-1212.

34- Titirici M.M., Demir-Cakan R., Baccile N., and Antonietti M. 2009. Carboxylate-Rich Carbonaceous Materials via One-Step Hydrothermal Carbonization of Glucose in the Presence of Acrylic Acid. Chem Mater, 21: 484-490.

35- Van Zwieten L., Kammann C., Cayuela M. L., Singh B., Joseph S., Kimber S., Clough T. J., and Spokas K. A. 2015. Biochar effects on nitrous oxide and methane emissions from soil. In: LEHMANN J. and JOSEPH S. (eds.) Biochar: Science, Technology and Implementation, 487-518.

36- Xu G., Lv Y., Sun J., Shao H., and Wei L. 2012. Recent Advances in Biochar Applications in Agricultural Soils: Benefits and Environmental Implications. Clean-Soil Air Water, 40: 1093-1098.

37-Yu Oy., Raichle B., and Sink S. 2013. Impact of biochar on the water holding capacity of loamy sand soil. International Journal of Energy and Environmental Engineering, 4: 1-9.